TS78M00A series 1-9 2003/12 rev. b TS78M00A series 3-terminal medium current positive voltage regulator pin assignment: 1. input 2. ground 3. output (heatsink surface connected to pin 2) voltage range 5v to 24v output current up to 0.5a general description the TS78M00A series positive voltage regul ators are identical to the popular ts7800 series devices, except that they are specified for only half the output cu rrent. like the ts7800 devices, the ts78m 00a series 3-terminal regulators are intended for local, on-ca rd voltage regulation. internal current limiting, thermal shut down circuitry and safe-area compensation fo r the internal pass transistor combine to make these devices remarkably rugged under most oper ating conditions. maximum output current with adequate heatsink is 500ma this series is offered in 3-pin to-220, to-252 package. features ? output current up to 0.5a ? no external components required ? internal thermal overload protection ? internal short-circuit current limiting ? output transistor safe-area compensation ? output voltage offered in 2% tolerance ordering information note: where xx denotes voltage option. part no. operating temp. (ambient) package ts78mxxacz to-220 ts78mxxacp -20 ~ +85 o c to-252 standard application a common ground is required between the input and the output voltages. the input voltage must remain typically 2.0v above the output volt age even during the low point on the input ripple voltage. xx = these two digits of the type number indicate voltage. * = cin is required if regulat or is located an appreciable distance from power supply filter. ** = co is not needed for stabilit y; however, it does improve transient response. absolute maximum rating input voltage vin * 35 v input voltage vin ** 40 v power dissipation to-220 to-220 to-252 without heatsink pt *** without heatsink 2 15 1 w operating junction temperature range t j 0 ~ +150 o c storage temperature range t stg -65 ~ +150 o c note : * ts78m05a to ts78m18a ** ts78m24a *** follow the derating curve .com .com .com 4 .com u datasheet
TS78M00A series 2-9 2003/12 rev. b ts78m05a electrical characteristics (vin=10v, iout=350ma, 0 o c tj 125 o c, cin=0.33uf, cout=0.1uf; unl ess otherwise specified.) parameter symbol test conditions min typ max unit tj=25 o c 4.90 5 5.10 output voltage vout 7.5v vin 20v, 5ma iout 350ma, pd 5w 4.80 5 5.20 v line regulation regline tj=25 o c 7.5v vin 25v, io=200ma -- 3 50 5ma iout 500ma -- 20 100 load regulation regload tj=25 o c 5ma iout 200ma -- 10 50 mv quiescent current iq iout=0, tj=25 o c -- 3 6 7.5v vin 25v -- -- 0.8 quiescent current change ? iq 5ma iout 350ma -- -- 0.5 ma output noise voltage vn 10hz f 100khz, tj=25 o c -- 40 -- uv ripple rejection ratio rr f=120hz, 8v vin 18v 62 80 -- db voltage drop vdrop iout=350ma, tj=25 o c -- 2 -- v peak output current io peak tj=25 o c -- 0.7 -- a temperature coefficient of output voltage ? vout/ ? tj iout=5ma, 0 o c tj 125 o c -- -0.2 -- mv/ o c ts78m06a electrical characteristics (vin=11v, iout=350ma, 0 o c tj 125 o c, cin=0.33uf, cout=0.1uf; unl ess otherwise specified.) parameter symbol test conditions min typ max unit tj=25 o c 5.88 6 6.12 output voltage vout 8.5v vin 21v, 5ma iout 350ma, pd 5w 5.76 6 6.24 v line regulation regline tj=25 o c 8.5v vin 25v, io=200ma -- 3 50 5ma iout 500ma -- 20 120 load regulation regload tj=25 o c 5ma iout 200ma -- 10 60 mv quiescent current iq iout=0, tj=25 o c -- 3 6 8.5v vin 25v -- -- 0.8 quiescent current change ? iq 5ma iout 350ma -- -- 0.5 ma output noise voltage vn 10hz f 100khz, tj=25 o c -- 45 -- uv ripple rejection ratio rr f=120hz, 9v vin 19v 59 80 -- db voltage drop vdrop iout=350ma, tj=25 o c -- 2 -- v output short circuit current ios tj=25 o c -- 50 -- ma peak output current io peak tj=25 o c -- 0.7 -- a temperature coefficient of output voltage ? vout/ ? tj iout=5ma, 0 o c tj 125 o c -- -0.2 -- mv/ o c z pulse testing techniques are used to maintain the juncti on temperature as close to the ambient temperature as possible, and thermal effects must be taken into account separately. z this specification applies only for dc power di ssipation permitted by absolute maximum ratings. .com .com .com .com 4 .com u datasheet
TS78M00A series 3-9 2003/12 rev. b ts78m08a electrical characteristics (vin=14v, iout=350ma, 0 o c tj 125 o c, cin=0.33uf, cout=0.1uf; unl ess otherwise specified.) parameter symbol test conditions min typ max unit tj=25 o c 7.84 8 8.16 output voltage vout 10.5v vin 23v, 5ma iout 350ma, pd 5w 7.68 8 8.32 v line regulation regline tj=25 o c 10.5v vin 25v, io=200ma -- 6 50 5ma iout 500ma -- 25 160 load regulation regload tj=25 o c 5ma iout 200ma -- 10 80 mv quiescent current iq iout=0, tj=25 o c -- 3 6 10.5v vin 25v -- -- 0.8 quiescent current change ? iq 5ma iout 350ma -- -- 0.5 ma output noise voltage vn 10hz f 100khz, tj=25 o c -- 52 -- uv ripple rejection ratio rr f=120hz, 11v vin 21v 56 80 -- db voltage drop vdrop iout=350ma, tj=25 o c -- 2 -- v output short circuit current ios tj=25 o c -- 50 -- ma peak output current io peak tj=25 o c -- 0.7 -- a temperature coefficient of output voltage ? vout/ ? tj iout=5ma, 0 o c tj 125 o c -- -0.2 -- mv/ o c ts78m09a electrical characteristics (vin=15v, iout=350ma, 0 o c tj 125 o c, cin=0.33uf, cout=0.1uf; unl ess otherwise specified.) parameter symbol test conditions min typ max unit tj=25 o c output voltage vout 11.5v vin 23v, 5ma iout 350ma, pd 5w line regulation regline tj=25 o c 11.5v vin 26v, io=200ma 5ma iout 500ma load regulation regload tj=25 o c 5ma iout 200ma quiescent current iq iout=0, tj=25 o c 11.5v vin 26v quiescent current change ? iq 5ma iout 350ma output noise voltage vn 10hz f 100khz, tj=25 o c ripple rejection ratio rr f=120hz, 12v vin 22v voltage drop vdrop iout=350ma, tj=25 o c output short circuit current ios tj=25 o c peak output current io peak tj=25 o c temperature coefficient of output voltage ? vout/ ? tj iout=5ma, 0 o c tj 125 o c z pulse testing techniques are used to maintain the juncti on temperature as close to the ambient temperature as possible, and thermal effects must be taken into account separately. z this specification applies only for dc power di ssipation permitted by absolute maximum ratings. .com .com .com .com 4 .com u datasheet
TS78M00A series 4-9 2003/12 rev. b ts78m10a electrical characteristics (vin=16v, iout=350ma, 0 o c tj 125 o c, cin=0.33uf, cout=0.1uf; unl ess otherwise specified.) parameter symbol test conditions min typ max unit tj=25 o c 9.80 10 10.20 output voltage vout 12.5v vin 25v, 5ma iout 350ma, pd 5w 9.60 10 10.40 v line regulation regline tj=25 o c 12.5v vin 28v, io=200ma -- 8 50 5ma iout 500ma -- 25 200 load regulation regload tj=25 o c 5ma iout 200ma -- 10 100 mv quiescent current iq iout=0, tj=25 o c -- 3 6 12.5v vin 28v -- -- 0.8 quiescent current change ? iq 5ma iout 350ma -- -- 0.5 ma output noise voltage vn 10hz f 100khz, tj=25 o c -- 70 -- uv ripple rejection ratio rr f=120hz, 13v vin 23v 55 80 -- db voltage drop vdrop iout=350ma, tj=25 o c -- 2 -- v output short circuit current ios tj=25 o c -- 50 -- ma peak output current io peak tj=25 o c -- 0.7 -- a temperature coefficient of output voltage ? vout/ ? tj iout=5ma, 0 o c tj 125 o c -- -0.3 -- mv/ o c ts78m12a electrical characteristics (vin=19v, iout=350ma, 0 o c tj 125 o c, cin=0.33uf, cout=0.1uf; unl ess otherwise specified.) parameter symbol test conditions min typ max unit tj=25 o c 11.76 12 12.24 output voltage vout 14.5v vin 27v, 5ma iout 350ma, pd 5w 11.52 12 12.48 v line regulation regline tj=25 o c 14.5v vin 30v, io=200ma -- 8 50 mv 5ma iout 500ma -- 25 240 load regulation regload tj=25 o c 0ma iout 200ma -- 10 120 quiescent current iq tj=25 o c, iout=0 -- 3 6 14.5v vin 30v -- -- 0.8 quiescent current change ? iq 5ma iout 200ma -- -- 0.5 ma output noise voltage vn 10hz f 100khz, tj=25 o c -- 75 -- uv ripple rejection ratio rr f=120hz, 15v vin 25v 55 80 -- db voltage drop vdrop iout=350ma, tj=25 o c -- 2 -- v output short circuit current ios tj=25 o c -- 50 -- ma peak output current io peak tj=25 o c -- 0.7 -- a temperature coefficient of output voltage ? vout/ ? tj iout=5ma, 0 o c tj 125 o c -- -0.3 -- mv/ o c z pulse testing techniques are used to maintain the juncti on temperature as close to the ambient temperature as possible, and thermal effects must be taken into account separately. z this specification applies only for dc power di ssipation permitted by absolute maximum ratings. .com .com .com .com 4 .com u datasheet
TS78M00A series 5-9 2003/12 rev. b ts78m15a electrical characteristics (vin=23v, iout=350ma, 0 o c tj 125 o c, cin=0.33uf, cout=0.1uf; unl ess otherwise specified.) parameter symbol test conditions min typ max unit tj=25 o c 14.70 15 15.30 output voltage vout 17.5v vin 30v, 5ma iout 350ma, pd 5w 14.40 15 15.60 v line regulation regline tj=25 o c 17.5v vin 30v, io=200ma -- 8 50 mv 5ma iout 500ma -- 25 300 load regulation regload tj=25 o c 5ma iout 200ma -- 10 150 quiescent current iq tj=25 o c, iout=0 -- 3 6 17.5v vin 30v -- -- 0.8 quiescent current change ? iq 5ma iout 350ma -- -- 0.5 ma output noise voltage vn 10hz f 100khz, tj=25 o c -- 90 -- uv ripple rejection ratio rr f=120hz, 18v vin 28v 54 70 -- db voltage drop vdrop iout=350ma, tj=25 o c -- 2 -- v output short circuit current ios tj=25 o c -- 50 -- ma peak output current io peak tj=25 o c -- 0.7 -- a temperature coefficient of output voltage ? vout/ ? tj iout=5ma, 0 o c tj 125 o c -- -0.3 -- mv/ o c ts78m18a electrical characteristics (vin=27v, iout=350ma, 0 o c tj 125 o c, cin=0.33uf, cout=0.1uf; unl ess otherwise specified.) parameter symbol test conditions min typ max unit tj=25 o c 17.64 18 18.36 output voltage vout 21v vin 33v, 5ma iout 350ma, pd 5w 17.28 18 18.72 v line regulation regline tj=25 o c 21v vin 33v, io=200ma -- 8 50 mv 5ma iout 500ma -- 25 360 load regulation regload tj=25 o c 5ma iout 200ma -- 10 180 quiescent current iq tj=25 o c, iout=0 -- 3 6 21v vin 33v -- -- 0.8 quiescent current change ? iq 5ma iout 350na -- -- 0.5 ma output noise voltage vn 10hz f 100khz, tj=25 o c -- 110 -- uv ripple rejection ratio rr f=120hz, 21v vin 31v 54 70 -- db voltage drop vdrop iout=350ma, tj=25 o c -- 2 -- v output short circuit current ios tj=25 o c -- 50 -- ma peak output current io peak tj=25 o c -- 0.7 -- a temperature coefficient of output voltage ? vout/ ? tj iout=5ma, 0 o c tj 125 o c -- -0.5 -- mv/ o c z pulse testing techniques are used to maintain the juncti on temperature as close to the ambient temperature as possible, and thermal effects must be taken into account separately. z this specification applies only for dc power di ssipation permitted by absolute maximum ratings. .com .com .com .com 4 .com u datasheet
TS78M00A series 6-9 2003/12 rev. b ts78m24a electrical characteristics (vin=33v, iout=350ma, 0 o c tj 125 o c, cin=0.33uf, cout=0.1uf; unl ess otherwise specified.) parameter symbol test conditions min typ max unit tj=25 o c 23.52 24 24.48 output voltage vout 27v vin 38v, 5ma iout 350ma, pd 5w 22.04 24 25.96 v line regulation regline tj=25 o c 27v vin 38v, io=200ma -- 10 50 mv 5ma iout 500ma -- 30 480 load regulation regload tj=25 o c 5ma iout 200ma -- 10 240 quiescent current iq iout=0, tj=25 o c -- 4 7 27v vin 38v -- -- 0.8 quiescent current change ? iq 5ma iout 350ma -- -- 0.5 ma output noise voltage vn 10hz f 100khz, tj=25 o c -- 170 -- uv ripple rejection ratio rr f=120hz, 27v vin 37v 50 70 -- db voltage drop vdrop iout=350ma, tj=25 o c -- 2 -- v output short circuit current ios tj=25 o c -- 50 -- ma peak output current io peak tj=25 o c -- 0.7 -- a temperature coefficient of output voltage ? vout/ ? tj iout=5ma, 0 o c tj 125 o c -- -0.5 -- mv/ o c z pulse testing techniques are used to maintain the juncti on temperature as close to the ambient temperature as possible, and thermal effects must be taken into account separately. z this specification applies only for dc power di ssipation permitted by absolute maximum ratings. .com .com .com .com 4 .com u datasheet
TS78M00A series 7-9 2003/12 rev. b electrical characteristics curve figure 1 - worst case power dissipation v.s. ambient temperature figure 2 - peak output current v.s. dropout voltage figure 3 ? quiescent current v.s. input voltage figure 4 ?dropout voltage v.s. junction temperature figure 5 ? quiescent current v.s. output current figure 6 ? to-252 thermal resistance and pd(max) v.s. p.c.b copper length .com .com .com .com 4 .com u datasheet
TS78M00A series 8-9 2003/12 rev. b electrical characteristics curve figure 7 ? ripple rejection v.s. frequency figure 8 ? ripple rejection v.s. output voltage .com .com .com .com 4 .com u datasheet
TS78M00A series 9-9 2003/12 rev. b to-220 mechanical drawing i j h e g f d c b a m n o l k p to-220 dimension millimeters inches dim min max min max a 10.000 10.500 0.394 0.413 b 3.240 4.440 0.128 0.175 c 2.440 2.940 0.096 0.116 d - 6.350 - 0.250 e 0.381 1.106 0.015 0.040 f 2.345 2.715 0.092 0.058 g 4.690 5.430 0.092 0.107 h 12.700 14.732 0.500 0.581 i 8.382 9.017 0.330 0.355 j 14.224 16.510 0.560 0.650 k 3.556 4.826 0.140 0.190 l 0.508 1.397 0.020 0.055 m 27.700 29.620 1.060 1.230 n 2.032 2.921 0.080 0.115 o 0.255 0.610 0.010 0.024 p 5.842 6.858 0.230 0.270 to-252 mechanical drawing b c d a f g i h e j to-252 dimension millimeters inches dim min max min max a 6.570 6.840 0.259 0.269 b 9.250 10.400 0.364 0.409 c 0.550 0.700 0.022 0.028 d 2.560 2.670 0.101 0.105 e 2.300 2.390 0.090 0.094 f 0.490 0.570 0.019 0.022 g 1.460 1.580 0.057 0.062 h 0.520 0.570 0.020 0.022 i 5.340 5.550 0.210 0.219 j 1.460 1.640 0.057 0.065 .com .com .com 4 .com u datasheet
|
